| Section 1 Identification |
| Product Number: | C1396 |
| Health: | 2 |
| Flammability | 2 |
| Reactivity | 0 |
Hazard Rating:
| Least | Slight | Moderate | High | Extreme |
| 0 | 1 | 2 | 3 | 4 |
NA = Not Applicable NE = Not Established
|
|
| Product Name: | 2-Butoxyethanol (Butyl Cellosolve®) Practical Grade |
| Trade/Chemical Synonyms | |
| Formula: | C–H‘”O’ |
| RTECS: | KJ8575000 |
| C.A.S | CAS# 111-76-2 |
| Section 2 Component Mixture |
| Sara 313 | Component | CAS Number | % | Dim | Exposure Limits: |
|
2-Butoxyethanol (Butyl Cellosolve®) | CAS# 111-76-2 | 100% | W/W | 50 ppm (240 mg/mƒ) OSHA TWA (SKIN) |
|
| Section 3 Hazard Identification (Also
see section 11) |
| May be fatal if inhaled, swallowed or absorbed thru the skin Avoid all contact. Use with adequate ventilation. Wash thoroughly after use. Keep container closed. |
| Section 4 First Aid Measures |
May be fatal if inhaled, swallowed or absorbed thru the skin Avoid all contact. Use with adequate ventilation. Wash thoroughly after use. Keep container closed.
FIRST AID: CALL A PHYSICIAN. SKIN: In case of contact, immediately flush skin with water for at least 15 minutes while removing contaminated clothing and shoes. Thoroughly clean clothing and shoes before reuse.
EYES: Wash eyes with plenty of water for at least 15 minutes, lifting lids occasionally. Seek Medical Aid. INHALATION: Remove to fresh air. If not breathing, give artificial respiration. If breathing is difficult, give oxygen
INGESTION: If swallowed, induce vomiting immediately after giving two glasses of water. Never give anything by mouth to an unconcious person.
|
| Section 5 Fire Fighting Measures |
| Fire Extinguisher Type: | Water spray, dry chemical, carbon dioxide, alcohol foam |
| Fire/Explosion Hazards: | None Known. |
| Fire Fighting Procedure: | Wear self-contained breathing apparatus and protective clothing to prevent contact with skin and clothing. |
|
|
| Section 6 Accidental Release
Measures |
Absorb spill with inert material, then place in a chemical waste container. RemoveDispose of in a manner consistent with federal, local law.
|
| Section 7 Handling and
Storage |
| Store in a cool dry well ventilated area. Keep away from heat and flame. Do not get in eyes, on skin, or on clothing. |
| Section 8 Exposure Controls
& Personal Protection |
Respiratory Protection:NIOSH/MSHA-approved respirator
Other Protective Equipment:
|
| Section 9 Physical and Chemical Properties |
| Melting Point: | information not available | Specific Gravity | 0.9
|
| Boiling Point: | 171°c |
Percent Volatile by Volume: | 100% |
| Vapor Pressure: | 0.6mmHg |
Evaporation Rate: | 0.06 |
| Vapor Density: |
4.07 |
Evaporation Standard: |
Butylacetate =1 |
| Solubility in Water: |
100% so;uble |
Auto ignition Temperature: |
Not applicable |
| Appearance and Odor: |
clear liquid |
Lower Flamm. Limit in Air: |
1.1% |
| Flash Point: |
160°c |
Upper Flamm. Limit in Air: |
10.6% |
|
| Section 10 Stability and Reactivity Information |
| Stability: Stable | Conditions to Avoid: High temperature |
Materials to Avoid:
Oxidizing agents, alkalies |
Hazardous Decomposition Products:
Carbon dioxide,peroxides |
| Hazardous Polymerization:Will Not Occur |
| Condition to Avoid:None known |
|
| Section 11
Additional Information |
| DANGER!! This material is ahemolytic agent and prolonged exposure will cause liver and kidney damage. Effects of over exposure: headache,nausea,dizziness,vomiting,tears,temporary clouding of the eyes,shortness of breathe and irratition of the eyes,nose and throat. Acute: prolonged exposure will make the effects of over exposure more severe. Chronic: none are listed by manufacturer however, it is stated that this material has not been fully investigated. Target organs: eyes,liver, kidneys, and upper respiratory tract. Conditions aggravated/target organs. Persons with pre-existing eye,skin,liver,kidney or respiratory conditions may be more susceptible. |
| DOT Classification: Combustible liquid, n.o.s. (2-Butoxyethanol), NA1993, PG III |
DOT regulations may change from time to time. Please
consult the most recent version of the relevant regulations.
| Revision No:0 | Date Entered: 9/1/2006 |
Approved by: WPF |
|
|
|