| Section 1 Identification |
| Product Number: | C1737 |
| Health: | 2 |
| Flammability | 0 |
| Reactivity | 0 |
Hazard Rating:
| Least | Slight | Moderate | High | Extreme |
| 0 | 1 | 2 | 3 | 4 |
NA = Not Applicable NE = Not Established
|
|
| Product Name: | Ferric Chloride 4.34% w/v |
| Trade/Chemical Synonyms | |
| Formula: | N/A |
| RTECS: | None |
| C.A.S | See Below |
| Section 2 Component Mixture |
| Sara 313 | Component | CAS Number | % | Dim | Exposure Limits: |
|
Water, Deionized ASTM Type II | CAS# 7732-18-5 | Balance | v/v | None Established |
|
Ferric Chloride | CAS# 10025-77-1 | 7.23% | W/V | OSHA TWA 1 mg(Fe)/mƒ |
|
Hydrochloric Acid | CAS# 7647-01-0 | <0.5% | V/V | OSHA PEL (C) 5 ppm, (C) 7 mg/mƒ |
|
| Section 3 Hazard Identification (Also
see section 11) |
| Harmful if swallowed. May cause irritation. Avoid breathing vapors, or dusts. Use with adequate ventilation. Avoid contact with eyes, skin, and clothes. Wash thoroughly after handling. Keep container closed. |
| Section 4 First Aid Measures |
Harmful if swallowed. May cause irritation. Avoid breathing vapors, or dusts. Use with adequate ventilation. Avoid contact with eyes, skin, and clothes. Wash thoroughly after handling. Keep container closed.
FIRST AID: SKIN: Remove contaminated clothing. Wash exposed area with soap and water. If symptoms persist, seek medical attention
EYES: Wash eyes with plenty of water for at least 15 minutes, lifting lids occasionally. Seek Medical Aid. INHALATION: Remove to fresh air. If not breathing, give artificial respiration. If breathing is difficult, give oxygen
INGESTION: If swallowed, induce vomiting immediately after giving two glasses of water. Never give anything by mouth to an unconcious person.
|
| Section 5 Fire Fighting Measures |
| Fire Extinguisher Type: | Any means suitable for extinguishing surrounding fire |
| Fire/Explosion Hazards: | None Known. |
| Fire Fighting Procedure: | Wear self-contained breathing apparatus and protective clothing to prevent contact with skin and clothing. |
|
|
| Section 6 Accidental Release
Measures |
Absorb spill with inert material, then place in a chemical waste container. Dispose of in a manner consistent with federal, local law.
|
| Section 7 Handling and
Storage |
| Store in a cool dry place. Do not get in eyes, on skin, on clothing. Wash thoroughly after handling |
| Section 8 Exposure Controls
& Personal Protection |
Respiratory Protection:None required
Other Protective Equipment:
Wear appropriate clothing to prevent skin exposure
|
| Section 9 Physical and Chemical Properties |
| Melting Point: | Information not available | Specific Gravity | not available
|
| Boiling Point: | Information not available |
Percent Volatile by Volume: | >90% |
| Vapor Pressure: | Information not available |
Evaporation Rate: | not available |
| Vapor Density: |
Information not available |
Evaporation Standard: |
|
| Solubility in Water: |
Soluble |
Auto ignition Temperature: |
Not applicable |
| Appearance and Odor: |
Clear yellow-brown odorless liquid |
Lower Flamm. Limit in Air: |
Not applicable |
| Flash Point: |
not flammable |
Upper Flamm. Limit in Air: |
Not applicable |
|
| Section 10 Stability and Reactivity Information |
| Stability: Stable | Conditions to Avoid: Contact with strong mineral acids. Excessive heat, and light |
Materials to Avoid:
Acidic conditions, Allyl chloride, Sodium, Potassium |
Hazardous Decomposition Products:
hydrochloric acid fumes |
| Hazardous Polymerization:not expected to occur |
| Condition to Avoid:None known |
|
| Section 11
Additional Information |
| If comes in contact with skin, flush with copious amounts of water. If irritation persists, get medical attention.If comes in contact with eyes flush for 15 minutes get medical attention. If inhaled move to fresh air. Breaathing mist can cause damage to nasal and respiratory passages. Swallowing results in severe damage to mucous membranes and deep tissues. Persons with pre-existig disorders may be more susceptible. |
| DOT Classification: Not Regulated |
DOT regulations may change from time to time. Please
consult the most recent version of the relevant regulations.
| Revision No:0 | Date Entered: 9/1/2006 |
Approved by: WPF |
|
|
|