| Section 1 Identification |
| Product Number: | C1776 |
| Health: | 3 |
| Flammability | 1 |
| Reactivity | 0 |
Hazard Rating:
| Least | Slight | Moderate | High | Extreme |
| 0 | 1 | 2 | 3 | 4 |
NA = Not Applicable NE = Not Established
|
|
| Product Name: | Formaldehyde (Formalin) 5% v/v Solution |
| Trade/Chemical Synonyms | |
| Formula: | N/A |
| RTECS: | None |
| C.A.S | See Below |
| Section 2 Component Mixture |
| Sara 313 | Component | CAS Number | % | Dim | Exposure Limits: |
|
Water, Deionized ASTM Type II | CAS# 7732-18-5 | Balance | v/v | None Established |
|
Formaldehyde, 37% | CAS# 50-00-0 | 5% | V/V | OSHA TWA 0.75 ppm(0.9mg/mƒ), STEL 2 ppm(2.5mg/mƒ) |
|
| Section 3 Hazard Identification (Also
see section 11) |
| May be fatal if inhaled, swallowed or absorbed thru the skin Avoid all contact. Use with adequate ventilation. Wash thoroughly after use. Keep container closed. |
| Section 4 First Aid Measures |
May be fatal if inhaled, swallowed or absorbed thru the skin Avoid all contact. Use with adequate ventilation. Wash thoroughly after use. Keep container closed.
FIRST AID: CALL A PHYSICIAN. SKIN: In case of contact, immediately flush skin with water for at least 15 minutes while removing contaminated clothing and shoes. Thoroughly clean clothing and shoes before reuse.
EYES: Wash eyes with plenty of water for at least 15 minutes, lifting lids occasionally. Seek Medical Aid. INHALATION: Remove to fresh air. If not breathing, give artificial respiration. If breathing is difficult, give oxygen
INGESTION: If swallowed, induce vomiting immediately after giving two glasses of water. Never give anything by mouth to an unconscious person.
|
| Section 5 Fire Fighting Measures |
| Fire Extinguisher Type: | Carbon Dioxide, dry chemical powder or appropriate foam |
| Fire/Explosion Hazards: | Thermal decomposition produces highly toxic fumes. |
| Fire Fighting Procedure: | Use water spray to cool fire exposed containers. Wear self-contained breathing apparatus and proper clothing to prevent contact with skin & clothing. |
|
|
| Section 6 Accidental Release
Measures |
Absorb spill with inert material, then place in a chemical waste container. Ventilate and wash spill site. Dispose of in a manner consistent with federal, local law.
|
| Section 7 Handling and
Storage |
| Store in a cool dry well ventilated area out of direct sunlight. Keep away from heat and flame. Do not get in eyes, on skin, or on clothing. |
| Section 8 Exposure Controls
& Personal Protection |
Respiratory Protection:NIOSH/MSHA-approved respirator
Other Protective Equipment:
Wear appropriate clothing to prevent skin exposure
|
| Section 9 Physical and Chemical Properties |
| Melting Point: | ~0° C | Specific Gravity | 1.0
|
| Boiling Point: | ~100° C |
Percent Volatile by Volume: | ~100% |
| Vapor Pressure: | not available |
Evaporation Rate: | N/E |
| Vapor Density: |
not available |
Evaporation Standard: |
N/A |
| Solubility in Water: |
Soluble |
Auto ignition Temperature: |
N/E |
| Appearance and Odor: |
Clear liquid, strong odor |
Lower Flamm. Limit in Air: |
Not available |
| Flash Point: |
not flammable |
Upper Flamm. Limit in Air: |
not available |
|
| Section 10 Stability and Reactivity Information |
| Stability: Stable | Conditions to Avoid: Avoid contact with incompatible materials. |
Materials to Avoid:
|
Hazardous Decomposition Products:
Toxic fumes of: Carbon Monoxide, Carbon Dioxide |
| Hazardous Polymerization:Will Not Occur |
| Condition to Avoid:None known |
|
| Section 11
Additional Information |
| Toxic! Carcinogen! Conditions aggravated/target organs: Persons with preexisting skin, eye or respiratory conditions may be more susceptible. Acute: May be fatal if inhaled, swallowed or absorbed through skin. Irritation or burns to skin, eyes, mucous membranes and upper respiratory tract. May cause allergic reactions, coughing, chest pains, pulmonary edema, GI tract disturbance. Effects may be delayed. Chronic: Carcinogen. Dermatitis, eye damage. |
| DOT Classification: Not Regulated |
DOT regulations may change from time to time. Please
consult the most recent version of the relevant regulations.
| Revision No:0 | Date Entered: 9/1/2006 |
Approved by: WPF |
|
|
|