| Section 1 Identification |
| Product Number: | C2036 |
| Health: | 2 |
| Flammability | 3 |
| Reactivity | 0 |
Hazard Rating:
| Least | Slight | Moderate | High | Extreme |
| 0 | 1 | 2 | 3 | 4 |
NA = Not Applicable NE = Not Established
|
|
| Product Name: | Maleic Anhydride Solution 2% w/v in Toluene |
| Trade/Chemical Synonyms | |
| Formula: | N/A |
| RTECS: | None |
| C.A.S | See Below |
| Section 2 Component Mixture |
| Sara 313 | Component | CAS Number | % | Dim | Exposure Limits: |
|
Maleic Anhydride | CAS# 108-31-6 | 2% | w/v | TXDS: orl-rat LD: 481 mg/Kg |
|
Toluene | CAS# 108-88-3 | Balance | v/v | OSHA TWA 200 ppm |
|
| Section 3 Hazard Identification (Also
see section 11) |
| Keep away from heat and ignition sources. Harmful if swallowed. Avoid breathing vapors. Use with adequate ventilation. Avoid contact with eyes, skin, and clothes. Wash thoroughly after handling. Keep container closed. |
| Section 4 First Aid Measures |
Keep away from heat and ignition sources. Harmful if swallowed. Avoid breathing vapors. Use with adequate ventilation. Avoid contact with eyes, skin, and clothes. Wash thoroughly after handling. Keep container closed.
FIRST AID: SKIN: Remove contaminated clothing. Wash exposed area with soap and water. If symptoms persist, seek medical attention
EYES: Wash eyes with plenty of water for at least 15 minutes, lifting lids occasionally. Seek Medical Aid. INHALATION: Remove to fresh air. If not breathing, give artificial respiration. If breathing is difficult, give oxygen
INGESTION: Give several glasses of milk or water. Vomiting may occur spontaneously, but DO NOT INDUCE! Never give anything by mouth to an unconscious person.
|
| Section 5 Fire Fighting Measures |
| Fire Extinguisher Type: | Carbon Dioxide, dry chemical powder or appropriate foam |
| Fire/Explosion Hazards: | Vapor may travel considerable distance to source of ignition and flash back. |
| Fire Fighting Procedure: | Use water spray to cool fire exposed containers. |
|
|
| Section 6 Accidental Release
Measures |
Eliminate ingition sources. Absorb spill with inert material, then place in a chemical waste container. Dispose of in a manner consistent with federal, local law.
|
| Section 7 Handling and
Storage |
| Store in a cool, dry, well-ventilated place away from incompatible materials. Wash thoroughly after handling. |
| Section 8 Exposure Controls
& Personal Protection |
Respiratory Protection:NIOSH/MSHA-approved respirator
Other Protective Equipment:
Wear appropriate clothing to prevent skin exposure
|
| Section 9 Physical and Chemical Properties |
| Melting Point: | -139F | Specific Gravity | 0.863
|
| Boiling Point: | 231F |
Percent Volatile by Volume: | 98% |
| Vapor Pressure: | 10mm Hg @ 70F |
Evaporation Rate: | 2.4 |
| Vapor Density: |
3.18 |
Evaporation Standard: |
Butylacetate =1 |
| Solubility in Water: |
0.6mg / Liter |
Auto ignition Temperature: |
Information not available |
| Appearance and Odor: |
Colorless liquid, strong aromatic odor |
Lower Flamm. Limit in Air: |
1% |
| Flash Point: |
40F |
Upper Flamm. Limit in Air: |
7% |
|
| Section 10 Stability and Reactivity Information |
| Stability: Stable | Conditions to Avoid: Avoid contact with heat, sparks, flames, or other sources of ignition. |
Materials to Avoid:
Strong oxidizers, metals, strong bases, amines |
Hazardous Decomposition Products:
Toxic fumes of: Carbon Monoxide, Carbon Dioxide |
| Hazardous Polymerization:Will Not Occur |
| Condition to Avoid:None known |
|
| Section 11
Additional Information |
| Conditions aggravated/target organs: Toxic! Persons with preexisting skin, eye and respiratory conditions will be more susceptible. Acute: Skin, eye, respiratory tract and digestive tract irritation, headache, dizziness, central nervous system effects, kidney and liver damage, cardiac arrest. Chronic: Dermatitis, defatting of skin, eye damage. |
| DOT Classification: Flammable liquid n.o.s. (Toluene), 3, UN1993, PG II |
DOT regulations may change from time to time. Please
consult the most recent version of the relevant regulations.
| Revision No:0 | Date Entered: 9/1/2006 |
Approved by: WPF |
|
|
|