| Section 1 Identification |
| Product Number: | C2206 |
| Health: | 3 |
| Flammability | 2 |
| Reactivity | 0 |
Hazard Rating:
| Least | Slight | Moderate | High | Extreme |
| 0 | 1 | 2 | 3 | 4 |
NA = Not Applicable NE = Not Established
|
|
| Product Name: | Perchloric Acid Titrant 0.01 Normal Acetous |
| Trade/Chemical Synonyms | |
| Formula: | N/A |
| RTECS: | |
| C.A.S | See Below |
| Section 2 Component Mixture |
| Sara 313 | Component | CAS Number | % | Dim | Exposure Limits: |
|
Acetic Acid, Glacial | CAS# 64-19-7 | Balance | V/V | 10 ppm OSHA TWA, 15 ppm OSHA STEL |
|
Acetic Anhydride | CAS# 108-24-7 | <0.5% | V/V | 5 ppm (20 mg/mƒ) OSHA TWA |
|
Perchloric Acid 70% w/w | CAS#: 7601-90-3 | 0.14% | W/V | STEL 3 mg/M3 TWA 1 mg/M3 |
|
| Section 3 Hazard Identification (Also
see section 11) |
| Causes severe irritation and burns. May Be harmful if swallowed. Avoid breathing vapor or dust. Use with adequate ventilation. Avoid contact with eyes, skin, and clothes. Wash thoroughly after handling. Keep container closed. |
| Section 4 First Aid Measures |
Causes severe irritation and burns. May Be harmful if swallowed. Avoid breathing vapor or dust. Use with adequate ventilation. Avoid contact with eyes, skin, and clothes. Wash thoroughly after handling. Keep container closed.
FIRST AID: CALL A PHYSICIAN. SKIN: In case of contact, immediately flush skin with water for at least 15 minutes while removing contaminated clothing and shoes. Thoroughly clean clothing and shoes before reuse.
EYES: Wash eyes with plenty of water for at least 15 minutes, lifting lids occasionally. Seek Medical Aid. INHALATION: Remove to fresh air. If not breathing, give artificial respiration. If breathing is difficult, give oxygen
INGESTION: Give several glasses of milk or water. Vomiting may occur spontaneously, but DO NOT INDUCE! Never give anything by mouth to an unconscious person.
|
| Section 5 Fire Fighting Measures |
| Fire Extinguisher Type: | Carbon Dioxide, dry chemical powder or appropriate foam |
| Fire/Explosion Hazards: | Vapor may travel considerable distance to source of ignition and flash back. |
| Fire Fighting Procedure: | Wear self-contained breathing apparatus and protective clothing to prevent contact with skin and clothing. |
|
|
| Section 6 Accidental Release
Measures |
Absorb spill with inert material, then place in a chemical waste container. Neutralize with a weak base.
|
| Section 7 Handling and
Storage |
| Keep away from heat and flame. Do not get in eyes, on skin, on clothing. Use with adequate ventilation. |
| Section 8 Exposure Controls
& Personal Protection |
Respiratory Protection:Organic Vapor Cartridge
Other Protective Equipment:
Wear appropriate clothing to prevent skin exposure. Use in well ventilated area or use respirator.
|
| Section 9 Physical and Chemical Properties |
| Melting Point: | 17 Deg C | Specific Gravity | 1.05
|
| Boiling Point: | 118 Deg C |
Percent Volatile by Volume: | 100 |
| Vapor Pressure: | 11 mmHg @20 C |
Evaporation Rate: | 0.97 |
| Vapor Density: |
2.1 (Air = 1) |
Evaporation Standard: |
|
| Solubility in Water: |
Soluble |
Auto ignition Temperature: |
Not applicable |
| Appearance and Odor: |
Clear pungent odor liquid (Strong Vinegar smell) |
Lower Flamm. Limit in Air: |
4% @59 deg C (103 F) |
| Flash Point: |
39 deg C (103 F) Closed Cup |
Upper Flamm. Limit in Air: |
19.3% @93 deg C (199 F( |
|
| Section 10 Stability and Reactivity Information |
| Stability: Stable | Conditions to Avoid: Material can react violently with strong oxidizing agents, metals, strong bases, amines. |
Materials to Avoid:
Oxidizers, strong bases, amines. |
Hazardous Decomposition Products:
Not known to occur |
| Hazardous Polymerization:Not known to occur. |
| Condition to Avoid:None known |
|
| Section 11
Additional Information |
| DANGER! CAUSES SEVERE IRRITATION AND BURNS! Harmpul if swallowed. Vapor irritating to the eyes and respiratory tract. May cause burns to the gastrointestinal tract if ingested. |
| DOT Classification: Corrosive Liquid, n.o.s. (Acetic Acid), 8, UN1760, PG II |
DOT regulations may change from time to time. Please
consult the most recent version of the relevant regulations.
| Revision No:0 | Date Entered: 9/1/2006 |
Approved by: WPF |
|
|
|